John Deere 7230R 7R Final Tier 4 (FT4) Series Tractors Maintenance Guide
Common sense goes a long ways when maintaining your machine. If you have extreme heat, dust, or terrain that you operate in you, service frequency will need to increase.
Service Schedule Parts for a John Deere 7230R 7R Final Tier 4 (FT4) Series Tractors
While your John Deere machine is certainly built with quality parts, they have a limited life. Good news is you can easily service your machine yourself using a John Deere maintenance kit or service kits or by getting the specific John Deere part needed to keep your John Deere mower or tractor running for a long time. These are the parts on your John Deere 7230R 7R Final Tier 4 (FT4) Series Tractors that need to be regularly serviced.
Part | Hour Interval | Price | |
---|---|---|---|
1 – Trailer Air Brake Dryer Cartridge AL204884 | Every Every 1500 |
|
|
1 – Secondary Air Filter F071151 | Every Inspect annually and replace as indicated |
|
|
1 – Fuel Tank Vent Filter H216169 | Every Every 1000 |
|
|
1 – Front PTO Filter LVU14258 | 250 hrs, then every 1500 hrs |
|
|
1 – Fuel Water Separator Filter N378886 | Every Clean after fifth back flushing of water separator assembly. |
|
|
1 – Fresh Air Filter RE284091 | Every 1000 or annually, whichever occurs first |
|
|
1 – Recirculation Air Filter RE291412 | Every 1000 or annually, whichever occurs first |
|
|
1 – Fresh Air Filter (Carbon) RE333567 | Every 1000 or annually, whichever occurs first |
|
|
1 – Recirculation Air Filter (Carbon) RE333569 | Every 1000 or annually, whichever occurs first |
|
|
1 – Engine: Oil Filter RE509672 | Initial oil change is 500 hours, then every 500 hours or annually, whichever occurs first. The extended 500 hour interval is only allowed if using Plus-50 II oil with a John Deere filter and diesel fuel with sulfur content less than 15mg/kg (15ppm). If all the conditions are not met, change oil and filter at 250 hours of operation. |
|
|
1 – Engine: Secondary Fuel Filter RE533910 | Replace every 500 hours, annually as indicated, whichever occurs first. |
|
|
1 – Oil Filter, Engine RE539279 | 100 hrs, then every 500 hrs and annually |
|
|
1 – Engine: Primary Fuel Filter RE539465 | Replace every 500 hours, annually as indicated, whichever occurs first. |
|
|
1 – Open Crankcase Ventilation (OCV) Filter RE540710 | Every Every 1500 |
|
|
1 – Fuel Filter Kit (Includes Primary and Secondary) RE541746 | Every Every 500 |
|
|
1 – Engine: Diesel Particulate Filter (DPF) RE541834 | Every Service as indicated by service lamp or diagnostic gauge. See tour John Deere or qualified service provider. |
|
|
1 – Primary Fuel Filter RE551507 | Every Every 500 |
|
|
1 – Diesel Exhaust Fluid (DEF) Dosing Unit Filter RE554498 | Every 4500 hrs or every three years of operation, whichever occurs first. |
|
|
1 – Primary Fuel Filter RE556406 | Every Every 500 |
|
|
1 – Secondary Fuel Filter RE560681 | Every Every 500 |
|
|
1 – Diesel Particulate Filter (DPF) RE563694 | Every Every 250 or as indicated |
|
|
1 – Primary Air Filter RE564863 | Every Inspect annually and replace as indicated |
|
|
1 – Oil Filter, Hydraulic/Transmission RE577060 | Every Every 1500 |
|
Commonly Used Parts for a John Deere 7230R 7R Final Tier 4 (FT4) Series Tractors
Outside of the schedule service intervals, you may need a part for a quick repair. While this is not an inclusive list of all the parts for a John Deere 7230R 7R Final Tier 4 (FT4) Series Tractors, these are the typical parts that we see purchased for your model.
Part | Price | |
---|---|---|
JD Diesel Exhaust Fluid Plus-50 II |
|
|
Cool-Gard II SWDEF025 |
|
|
Hy-Gard TY26573 |
|
|
TY6354 |
|
As Needed Parts for a John Deere 7230R 7R Final Tier 4 (FT4) Series Tractors
Regardless of your John Deere model, these John Deere parts are used frequently in maintaining and your John Deere 7230R 7R Final Tier 4 (FT4) Series Tractors and can be used around your garage.
Part | Price |
---|